application of Epoxy paint to the Garage Flooring

Often we don’t think about our garages or pay much attention to their appearance. They are merely a destination to park the autos and store the extra boxes of Holiday adornments and such. However, like any other room in your own home your storage area floor must be taken good care of.
Due to the put it to use gets, combined with water, gas and oil that will unavoidable be spilled after it, garage flooring can simply become harmed and begin to fall apart over time useful. Epoxy coating is one way to your garage floor challenge. Epoxy finish applies a part of sealant and protectant to your concrete garage floor to make it avoid staining, moisture problems and helps it maintain its appearance.
Installing epoxy floor takes a little up-front prep before beginning. The most important step in the process is ensuring the floor you are going to apply the epoxy covering onto is free from moisture, residual color and doesn’t have a concrete sealer or other concluding applied to it.
To test for moisture, have a sheet of plastic and take it to a 3-feet x 3-foot area using masking tape. Keep it there for about two days and nights and then remove and look for any moisture collecting on the side of the clear plastic facing the ground. If moisture is present, than an epoxy flooring finish is not suitable as epoxy needs a dried up surface to properly connection with the floors.
Next, we’ll test to make certain the flooring does not have a sealant already applied to it. This test will also check for the presence of oils in the concrete as well. Take a cup of normal water and pour it immediately onto the existing flooring. It will soak into the floor in a reasonable timeframe. If it beads or perhaps sits together with the flooring then your floor coverings has probably recently been sealed or contains oil contaminants. Epoxy flooring is not ideal for cement floors that have already been sealed or contain any type of oil residue as you won’t bond.
Finally, if you are prepared to spend almost a year testing a location of your garage area floor for suitability to setting up epoxy flooring you can coloring a small area with regular, oil-based enamel. If this test area endures for several a few months then it is likely an epoxy finish will last as well. However, if you decide to proceed with applying the epoxy finish you’ll need to eliminate this enamel layer that may require sanding.

Leave a Reply

Your email address will not be published. Required fields are marked *